All Issue

2015 Vol.14, Issue 1 Preview Page
Behavior Characteristics of Underground Flexible Pipe Backfilled with Lightweight Foamed Soil

경량기포혼합토로 뒷채움된 연성매설관의 거동특성

Yong-Jae Lee1
,
Geu-Guwen Yea2
,
Sang-Won Park3
,
Hong-Yeon Kim3*
이 용재1
,
여 규권2
,
박 상원3
,
김 홍연3*
1Managing Director, Civil Works Division, SAMBU Construction Co.
2Head of Office, Technology Research Division, SAMBU Construction Co.
3Senior Researcher, Technology Research Division, SAMBU Construction Co.
*교신저자. *Corresponding Author. 
30 March 2015. pp. 43-50
PDF XML Citation
Abstract

Lightweight Foamed Soil (LWFS) is a useful material for underground pipe backfill because of reusability of excavated soil and no compaction effect. In this research, a pilot test is carried out and monitoring results are analyzed to investigate behaviors of a flexible pipe, when LWFS is applied as a backfill material. Simultaneously, they are compared with another test case which is backfilled with Saemangeum dredged soil. As a result, the vertical earth pressure of the case backfilled with LWFS slurry presents that decreases as much as 25.6% in comparison with dredged soil and it is only within 10% after solidification. In case backfilled with dredged soil, the horizontal earth pressure is more than 3.6 times of the case used by LWFS and the vertical and horizontal deformation is more than 3.2 and 2.6 times of the case, respectively. It presents excellent effects on earth pressure and deformation reduction of LWFS. The stresses measured at the upper side of the pipe generally present compressive aspects in case backfilled with dredged soil. However, they present tensile aspects in case of LWFS. It is because of negative moment occurred at the center of the pipe due to the buoyancy from LWFS slurry. Conclusively, LWFS using Saemangeum dredged soil is very excellent material to use near the area in comparison with the dredged soil. However, the countermeasure to prevent the buoyancy is required.

Keywords
Lightweight foamed soil
Pipe
Backfill material
Earth pressure
Deformation

본 연구에서는 현장잔토를 활용할 수 있고 다짐이 불필요하여 관로공사에 유용한 경량기포혼합토를 지중매설관의 뒷채움재로 이용할 경우 관로의 거동을 조사하기 위하여 시험시공을 실시하고 계측결과를 분석하였다. 동시에 동일한 조건의 새만금 준설토사 뒷채움 시공결과와 비교하였다. 연직토압의 경우 경량기포혼합토 뒷채움 시 준설토사 대비 초기 슬러리 상태에서 25.6% 가량 저감되었고 양생 후에는 준설토사 토압의 10% 이내에 불과하였다. 준설토사 뒷채움 시에는 경량기포혼합토 대비 수평토압의 경우 3.6배 이상, 연직 및 수평변위는 각각 3.2배와 2.6배 가량의 차이를 나타내어 경량기포혼합토의 토압 및 변위저감 효과가 우수한 것으로 나타났다. 매설관 상반부에서 측정된 응력의 경우 토사 뒷채움 시 대체로 압축응력이 발생한 반면, 경량기포혼합토를 타설한 경우 초기 슬러리 상태에서 발생한 부력으로 인하여 고정된 양단부를 지점으로 부(-)의 모멘트가 발생함으로써 상반부에 인장응력이 발생하는 결과를 얻었다. 결론적으로, 새만금에서 준설된 토사를 이용한 경량기포혼합토는 인근 개발지에서 매설관 뒷채움재로 활용하는데 있어 준설토사와 비교하여 매우 우수한 재료이나 타설 시 부력에 대한 대책이 필요하다.

References
1
1.ACI Committee 229 (1994), CLSM, ACI 229 R-94.
2
2.Cho, D. (2005), “Application of Liquefied Stabilization Method Using In-Situ Soil”, Harmony of the Nature and Civilization, Vol.53, No.10, pp.119-125.
3
3.Duncan, J. M. and Seed, R. B. (1986), “Compaction-induced earth pressures under K0-conditions”, Journal of Geotechnical Engineering, Vol.112, No.1, pp.1-21.
4
4.Jo, S., Cho, G., Lim, Y. and Lee, J. (2010), “Study on Engineering Property of Lightweight Foam-mixed materials”, Proc. of KSCE Annual Conference 2010, pp.473-476.
5
5.Kim, H., Kim, Y., Kang, I., Kim, K., Park, J. and Park, S. (2001) “Material Characteristics and Practical Use of Lightweight Fills Mixed Weathered Granite Soils and EPS Beads”, Proc. of Geosynthetics Conference, pp.257-264.
6
6.Kim, T. S., Jeong, S. S., Lee, D. S. and Kim, D. H. (2007), “Deformation Characteristics of Quick-set Flowable Backfill Materials Using Excavated Soil for Underground Power Cables”, Journal of KSCE, Vol.27, No.1C, pp.45-53.
7
7.Lee, K. H. and Park, J. H. (2006), “Evaluation of Construction Operation and Design Properties of CLSM for Corrugated Pipe in Underground”, Journal of KSRE, Vol.8, No.2, pp. 63-74.
8
8.Lee, K., Kim, J., Hyun, S., Song, Y. and Lee, B. (2007), “Defromation Behavior of Underground Pipe with controlled Low Strength Materials with Marine Dredged Soil”, Journal of the Korean Society of Hazard Mitigation, Vol.7, No.5, pp.129-137.
9
9.Park, J., Cho, J., Lee, K. and Kim, Y. (2003), “Deformation Characterization of Underground Pipe Using Model Chamber Test”, Proc. of KSRE Conference, Vol.5, pp.271-278.
10
10.Park, Y. and Kim, S. (2009), “Economic Analysis of Box Mechanical Behavior Materials Using LCC Analysis”, Journal of Construction Management, Vo.10, No.6, pp.40-47.
11
11.Yoon, G. L., Yoon, Y. W. and Ahn, K. H. (2012), “Shear Strength and Deformation Characteristics of Lightweight Soils Mixed with Tire Powder”, Journal of KSCE, Vol.32, No.6C, pp.259-265.
Information
  • Publisher :Korean Geosythetics Society
  • Publisher(Ko) :한국지반신소재학회
  • Journal Title :Journal of the Korean Geosynthetics Society
  • Journal Title(Ko) :한국지반신소재학회 논문집
  • Volume : 14
  • No :1
  • Pages :43-50
  • Received Date : 2014-12-04
  • Revised Date : 2015-01-18
  • Accepted Date : 2015-01-19
  • DOI :https://doi.org/10.12814/jkgss.2015.14.1.043
Journal Informaiton Journal of the Korean Geosynthetics Society Journal of the Korean Geosynthetics Society
  • NRF
  • KOFST
  • KISTI Current Status
  • KISTI Cited-by
  • crosscheck
  • orcid
  • open access
  • ccl
Journal Informaiton Journal Informaiton - close